Quality ignition coil factory: Diagnosing a Bad Ignition Coil: Ignition coils typically have a long life of operation — over 100,000 miles. However, they can malfunction eventually, causing that dreaded misfire. This issue will probably start out slowly while being hardly noticeable but will become more problematic over time. When a misfire occurs, even for a few seconds, your engine computer management will likely detect the issue and generate a trouble code. At which point the check engine light comes on. With a diagnostic scanner at a garage or auto parts store, you can then see which cylinder is misfiring and proceed from there. Another sign of a misfire can be a rough engine idle. In extreme cases, the vehicle may feel like it’s surging at a high RPM or like it may stall at low speeds. Other signs that you have a bad ignition coil are worsening gas mileage, sluggish acceleration and a backfiring engine, meaning you hear a loud bang as unburned fuel escapes from the exhaust system. Discover additional details on ignition coil manufacturers.

A modern ignition coil just looks like a rubber boot that slips onto its spark plug. Up top, there’s an electrical connector for receiving voltage and some threads to mount it securely on the engine. If you were to dissect the component, however, you would find several meters of tightly wound copper wiring that make up the coil pack. These are wrapped around an iron core which receives the 12V current to serve as an electromagnet. The energy stored in the magnetic field of the core is the energy that is transferred to the spark plug. Lastly, the whole coil pack is embedded in a resin insulator to prevent short-circuiting. The ignition coil uses a principle known as Faraday’s law of induction to produce incredible amounts of power, and the same law applies when constructing electric motors as well as generators.

What is the reason? Here are some of them: The spark plug gap is too large, adjust the gap or replace the spark plug; The gasoline quality is not good, try changing to a higher-grade gasoline; The cylinder compression ratio is wrong, adjust the compression ratio; If there is a program failure on the computer board, you can go to the repair shop to test the car with a computer and clear the error message. If it doesn’t work, there may be a problem with your car’s transmission. Ignition coil manufacturer has more than 30 years of production experience.

Using a collapsing magnetic field to induce an electric current: When a magnetic field has been created by applying an electric current to a coil of wire, any change in the electric current (increase or decrease in current flow) creates the same change in the magnetic field. If the electric current is switched off, the magnetic field will collapse. The collapsing magnetic field will then induce an electric current into the coil. If an electric current used to create a magnetic field is switched off, the magnetic field collapses, which induces another electric current into the coil.

The first coil-based ignition system is credited to the American inventor Charles Kettering, who developed a coil ignition system for a major vehicle manufacturer around 1910/1911. For the first time, he devised an electrical system that powered the starter motor and ignition at the same time. The battery, a generator and a more complete vehicle electrical system provided a relatively stable electrical supply to the ignition coil. The Kettering system used a single ignition coil to produce a high voltage, which was passed to a rotor arm that effectively pointed the voltage to a series of electrical contacts located in the distributor assembly (one contact for each cylinder). These contacts were then connected by spark plug wires to the spark plugs in a sequence that made it possible to distribute the high voltage to the spark plugs in the correct cylinder firing order.

Haiyan engine coil wholesale manufacturer carries out strict quality monitoring and cost control on each production link of car coil, from raw material purchase, production and processing and finished product delivery to packaging and transportation. This effectively ensures the car coil of Haiyan ignition coil suppliers has better quality and a more favourable price than other products in the industry. The ignition coil wholesale manufacturer provide comprehensive and professional services such as design solutions and technical consultations based on the actual needs of customers. Read extra details at hj-auto.com.

Haiyan is a professional ignition coil manufacturer & supplier, specialising in car ignition coil, plug coil and spark coil. Haiyan ignition coil manufacturer products contain high-quality car ignition coil, engine coil, ignition coil packs, tool cabinets, hardware accessories, and precision matching pieces of Japanese host. Every year the production quantity of ignition coils reach 1,000,000 PCS, cars spare parts reach 2,000,000 sets and 3,000,000 sets of Japanese hosts accessories.